May be a bad Thermistor
from the Tech Sheet - 3977696
Thermistor Test or Dryer Beeps 3 Times When PTS Pressed
An electronic temperature sensor called a thermistor is used in this model in place of an operating thermostat.
The Even Heat control monitors the exhaust temperature using the thermistor and cycles the heater relay on and off to maintain the desired temperature.
Begin with an empty dryer and a clean lint screen.
1. Set the following configuration:
Timer Dial - TIMED DRY
Fabric Care/Temperature switch - COTTON HIGH
Signal switch - LOUD
Door - must be closed
2. Press the Push To Start switch.
a. If you hear three short beeps and the dryer shuts off after several seconds,
the thermistor or wire harness is either shorted or open.
Check wire connections at Even Heat control and thermistor.
If wiring is functional, replace the thermistor:
b. If the dryer appears to operate correctly, proceed to step 3.
3. Remove exhaust vent and start the dryer.
a. Turn Fabric Care/Temperature switch to desired temperature to be tested,
and select 20 minutes on the TimedDry dial.
Hold a glass bulb thermometer capable of reading from 90°F to 180°F in the center of the exhaust outlet.
Measure exhaust temperatures with heater off and on.
The correct exhaust temperatures are as follows:
SWITCH SETTING . . . . HEAT TURNS OFF. . . . . . . . HEAT TURNS ON
COTTON . . .. . . . . . . . 150°F . . . . . . . . . 10° - 15°F below heat off
NORMAL/PERM PRESS 140°F . . . . . . . . . . 10° - 15°F below heat off
KNIT/CASUAL . . . . . . . 125°F . . . . . . . . . . 10° - 15°F below heat off
ULTRA DELICATE . . . . . 115°F . . . . . . . . . .10° - 15°F below heat off
b. If the exhaust temperature is not within specified limits, check the resistance of the thermistor.
TEMP ° F . . . . . RES. K . . . . . TEMP. ° F . . . . . RES. K
50° 19.9 100° 5.7
60° 15.3 110° 4.7
70° 11.9 120° 3.7
80° 9.2 130° 3.1
90° 7.4 140° 2.5
c. If the thermistor resistance checks within normal limits, replace the Even Heat control.
Stay connected with us...
Webinar Recordings Index Page 10/03/2017On-demand appliance repair training videos for Professional Appliantologist members Over 30 hours (and growing!) of original, high quality appliance training webinars developed and given by yours truly are at your fingertips, on topics you won't find anywhere else. Fill in those knowledge gaps, strengthen those areas of uncertainty, and boost your skills. Watch on mobile or desktop at your convenience whenever, wherever. Ultra Short Primer on Basic Electricity, Circuits, Ohm's Law, and Schematic Reading (Length: 1:04:48) Basic Refrigerator Troubleshooting (Length: 1:10:45) Schematic Reading Workshop, 10/2015 (Length 1:19:08) Troubleshooting Strategies for Computer-Controlled Appliances (Length: 48:34) Semiconductors and PN Junctions (Length: 1:04:37) Appliance Temperature Sensing Devices & Technology (Length: 1:27:33) Voltage Measurements, Meters, Ghost Voltages, and Triac-controlled Neutrals (Length: 1:29:32) Troubleshooting with Tech Sheets, Part 1, 4/2016 (Length: 1:09:26) Troubleshooting with Tech Sheets, Part 2, 4/2016 (Length: 1:21:11) Tech Sheet Review, 4/9/2016: Bosch Speed Cooker, Amana Refrigerator, GE Glass Cooktop Range (Length: 1:22:58) Pulse Width Modulated (PWM) Switches used in Samsung Switched Mode Power Supplies (SMPS) (Length: 27:07) PWM Computer Cooling Fan in a Whirlpool Refrigerator (Length: 14:53) Understanding AC Split-phase Household Power Supplies (Length: 52:41) Troubleshooting a Samsung Electric Dryer without Disassembly using Live Tests and the Schematic (Length: 22:47) Troubleshooting a Bosch Dishwasher No-Heat Problem using the Schematic and Live Tests (Length: 15:38) Linear Motors and Linear Compressors (Length: 55:54) Bi-directional PSC Drive Motor Systems in Whirlpool VM Washers (Length: 56:52) Appliance Service Call Structure and Troubleshooting Strategies (Length: 1:00:16) The Ten Step Troubleshooting Tango and Workshop Exercises (Length: 1:35:39) Troubleshooting Ten-Step Tango Advanced Workshop (Length: 1:32:06) Ten-Step Tango Troubleshooting Workshop: Refrigerators (Length: 1:35:57) Whirlpool Duet Washer Schematic Analysis & Whirlpool Dryer Moisture Sensor System (Length: 1:03:04) Neutral Vs. Ground, Inverter Microwave, Digital Communications, Loading Down in DC loads, and more! (Length: 1:14:45) Gas Oven Service Call After a Parts Changing Monkey (Length: 36:04) AFCI and GFCI Circuit Protection Technology (Length: 41:26) Troubleshooting Samsung Refrigerators and more (Length: 1:29:58) 3-way Valves and Dual Evaporator Refrigerators (Length: 1:15:45) Split-Phase Compressors and PTC Start Devices (Length: 1:11:57) Gas Dryer Ignition Systems (Length: 53:50) Refrigerator Sealed System Thermodynamics, Part 1 (Length: 43:07) Refrigerator Sealed System Thermodynamics, Part 2 (Length 1:09:09) To access these webinars and all the other info-goodies here at Appliantology, become a Professional Appliantologist today. If you need cost-effective, time-flexible, state-of-the-art appliance technical training, check out the Master Samurai Tech Academy.